廚房安裝排煙管道要考慮的五方面問題

發布人：http://www.bnlfans.net   發布時間：2022-08-15 17:09:00

廚房排煙管道很重要，安裝使用時一定要特別注意幾個事項，比如管道的通風面積，低層排煙不暢，如下：

The smoke exhaust pipe in the kitchen is very important. During installation and use, special attention must be paid to several matters, such as the ventilation area of the pipe and the poor smoke exhaust on the lower floor, as follows:

排煙管道

Smoke exhaust pipe

一、主排氣管通風面積不足。

1、 The ventilation area of the main exhaust pipe is insufficient.

根據工程經驗，主排氣管內風速不能超過15m/s，否則運行一段時間后排氣系統容易堵塞。在油煙凈化器的運行實踐中，大多數情況是由于排氣管通風面積不足造成的，管內氣體流速在15m/s以上。

According to the engineering experience, the wind speed in the main exhaust pipe shall not exceed 15m / s, otherwise the exhaust system will be easily blocked after a period of operation. In the operation practice of the oil fume purifier, most cases are caused by insufficient ventilation area of the exhaust pipe, and the gas flow rate in the pipe is above 15m / s.

二、管道截面積變小。

2、 The cross-sectional area of the pipe becomes smaller.

由于排煙管道會穿過建筑橫梁，導致氣流不暢，排氣管的通風橫截面積會減小，橫截面上的阻力會增加。

As the smoke exhaust pipe will pass through the building beam, resulting in poor airflow, the ventilation cross-sectional area of the exhaust pipe will be reduced, and the resistance on the cross-section will be increased.

三、管道使用后會堆積。

3、 Pipes will accumulate after use.

當排煙管道穿過建筑橫梁或避開其他設備管道時，一段排煙管會低于整個排煙管的平面。使用一段時間后，油水混合物會堆積在排煙管的下部，直接影響排煙的順暢性。

When the smoke exhaust pipe passes through the building beam or avoids other equipment pipes, a section of smoke exhaust pipe will be lower than the plane of the whole smoke exhaust pipe. After using for a period of time, the oil-water mixture will accumulate in the lower part of the smoke exhaust pipe, directly affecting the smoothness of smoke exhaust.

四、低層排煙不順暢

4、 Smoke exhaust on the lower floor is not smooth

不同樓層的廚房油煙通過同一主管道排出，靠近出口的樓層排煙效果較好，而較低樓層排煙不暢。

The kitchen fume of different floors is discharged through the same main pipe. The smoke exhaust effect of the floor near the exit is better, while the smoke exhaust of the lower floor is not smooth.

五、建議配備排煙風機

5、 Smoke exhaust fan is recommended

對于高油煙的廚房，建議配備排煙風機。常用的排煙風機有軸流風機、風機箱和離心風機。

For kitchens with high oil smoke, it is recommended to provide smoke exhaust fans. The commonly used smoke exhaust fans include axial flow fans, fan boxes and centrifugal fans.

以上就是為大家介紹的有關濟南風管加工廠的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.bnlfans.net

The above is the detailed introduction of Jinan air duct processing factory. I hope it will help you. If you have any questions, please contact us. We will provide you with services with a professional attitude http://www.bnlfans.net